Product ID:LORD 7713
MSDS Date:11/21/1989
FSC:8040
NIIN:00N042106
MSDS Number: BSVCP

LORD CORP

2000 WEST GRANDVIEW BLVD
ERIE, PA 16514-0038
US

Emergency Phone: 814-763-2345

Info Phone: 814-868-3611

Preparer: KWM

Cage: DO802

LORD CORPORATION, CHEMICAL PRODUCTS DIVISION

ERIE, PA 16514-0038 US

Telephone: 814-868-3611

Cage: 30676

LIFE-SUSTAINING USES IN HUMANS ACUTELY OR

RTECS: 9999999ZZ

NOT BE REUSED. DO NOT GET IN EYES. AVOID SKIN

RTECS: 9999999ZZ

SKIN RXN. PVNT PRLNGD/RPTD BRTHG OF VAP/SPRAY MISTS.

RTECS: 9999999ZZ

UNDERSTOOD. DO NOT WELD/FLAME-CUT AN EMPTY DRUM.

RTECS: 9999999ZZ

PARTS. THIS PROD CONTAINS CHLORINATED SOLVS. NO

RTECS: 9999999ZZ

WELDING, OPEN FLAMES OR HOT SURFS. HEAT AND/OR UV

RTECS: 9999999ZZ

EATING, SMOKING/USING WASH ROOM. DO NOT

RTECS: 9999999ZZ

SHOULD NOT BE CONSUMED ANYWHERE THIS PRODUCT IS

RTECS: 9999999ZZ

ANTICIPATED

RTECS: 9999999ZZ

METHANE, DICHLORO-; (METHYLENE CHLORIDE) (SARA III). VP

CAS: 75-09-2

RTECS: PA8050000

Fraction By Weight: 35%

OSHA PEL 500 PPM, 1000 C

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ETHYLENE, TRICHLORO-; (TRICHLOROETHYLENE) (SARA III). VP

CAS: 79-01-6

RTECS: KX4550000

Fraction By Weight: 55%

OSHA PEL 50 PPM;200 PPM STEL

ACGIH TLV: 50 PPM;200 PPM STEL

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

ISOCYANIC ACID, METHYLENEDI-P-PHENYLENE ESTER; (METHYLENE

CAS: 101-68-8

RTECS: NQ9350000

Fraction By Weight: 50%

OSHA PEL 0.02 PPM, C

ACGIH TLV: 0.005 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

SYS. CHLOROCARBON MATLS HAVE PRDCED SENSIT

RTECS: 9999999ZZ

HAVE SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS (E.G.,

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:POSS IRRIT OF RESP SYS CAUSING
VARIETY OF SYMPS SUCH AS DRYNESS OF THROAT, TIGHTNESS OF CHEST,&
SHORTNESS OF BRTH. ALLERGIC CNDTNS CAN OCCUR IN CERTAIN INDIVS
W/HIGH SENSITIVITY TO ISOCYANATES. THIS MAY RSLT IN ASTHMA-LIKE
SYMPS. ANESTHETIC. RESP IRRIT.SKIN IRRIT. EYE IRRIT.MAY CAUSE CNS
DEPRESS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: IARC MONOGRAPHS,
SUPPLEMENT. VOL 7, PG 194, 1987: IARC CANCER REVIEW: GRP 2B. NTP
7TH ANNUAL(ING 14)
Effects of Overexposure:HLTH HAZ: CHARACT BY FOLLOWING PROGRESSIVE
STEPS: HDCH, DIZZ, STAG GAIT, CONFUSN, UNCON/COMA. MAY CAUSE HDCH &
NAUS. CHRONIC: MAY CAUSE SKIN SENSIT. MAY CAUSE DERM. MAY CAUSE
RESP SENSIT. MAY CAUSE LI VER/KIDNEY DMG. RPTD/PRLNGD SOLV OVEREXP
MAY RSLT IN PERM CNS DMG. MAY CAUSE LONG-TERM LUNG DMG. MAY AFFECT
GI (ING 4)
Medical Cond Aggravated by Exposure:RESPIRATORY ALLERGIES. CHRONIC
DISEASES OF SKIN. CHRONIC DISEASES OF NOSE, THROAT AND RESPIRATORY
TRACT. CHRONIC DISEASES OF CNS. CHRONIC DISEASES OF LIVER/KIDNEY.
CHRONIC DISEASES OF GI TRACT.

First Aid:INHAL: MOVE PERSON TO FRESH AIR. RESTORE BRTHG. TREAT
SYMPTOMATICALLY. CONSULT PHYS. EYES: FLUSH IMMED WITH LRG AMTS OF
WATER FOR AT LST 15 MINS. TAKE TO PHYS FOR MED TREATMENT. SKIN:
WASH AFFECTED AR EAS WITH SOAP AND WATER. REMOVE CONTAMDCLTHG.
CONSULT PHYSICIAN IF IRRIT PERSISTS. INGEST: DRINK 1-2 GLASSES OF
WATER TO DILUTE. DO NOT INDUCE VOMIT. CONSULT PHYS/POIS CNTRL CNTR
IMMED. TREAT SYMP.

Flash Point:200F,93C
Lower Limits:12%
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG, HALON 1211.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESS DEMAND SCBA &
FULL PROT EQUIP . IF WATER USED,FOG NOZZ ARE PREF. WATER MAY BE
USED TO COOL CLSD CNTNRS TO PVNT PRESS (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT,ELEC EQUIP, SPARKS & OPEN FLAME.CLSD CNTNRS MAY EXPLO WHEN
EXPOS TO EXTREME HEAT. WATER MAY BE USED TO COOL (SUPDAT)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION (FLAME, HOT
SURFACES, AND ELECTRICAL, STATIC OR FRICTIONAL SPARKS). AVOID
BREATHING VAPORS. USE NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING
EQUIPMENT. VENTILATE AREA. C ONTAIN AND REMOVE WITH INERT ABSORBENT
MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE/USE NEAR HEAT/OPEN FLAME.
REFER TO OSHA 29CFR PART 1910.106 FOR SPECIFIC STORAGE REQS.KEEP
CLOSURE TIGHT & CNTNR UPRIGHT TO PVNT LEAKAGE.
Other Precautions:STORE DRUM OUT OF SUN & AWAY FROM HEAT.RELIEVE
INTERNAL PRESS WHEN RECEIVED & AT LST WEEKLY THEREAFTER BY SLOWLY
LOOSENING CLOSURE. RETIGHTEN IMMED.STORE ONLY IN WELL-VENT AREAS.DO
NOT PUNCTURE, DRAG/ SLIDE CNTNR. EMPTY DRUMS SHOULD (ING 7)

Respiratory Protection:PRODUCT CONTAINS ISOCYANATES WHICH HAVE POOR
WARNING PROPERTIES. IF OCCUP EXPOSURE LIMITS ARE EXCEEDED, A
NIOSH/MSHA APPROVED SUPPLIED AIR RESP SHOULD BE USED. USE
NIOSH/MSHA APPROVED AIRLINE TYPE RES PIRATORS OR HOODS IN CONFINED
AREAS.
Ventilation:SUFF VENT, IN PATTERN & VOL, SHOULD BE PROVIDED TO KEEP AIR
CONTAM CONC BELOW APPLIC EXPOS LIMITS. USE VENT TO (SUPDAT)
Protective Gloves:NEOPRENE OR RUBBER GLOVES.
Eye Protection:ANSI APRV CHEM WORK GOGG.
Other Protective Equipment:USE DISPOSABLE/IMPERVIOUS CLTHG IF WORK
CLTHG CONTAMINATION IS LIKELY. USE PROTECTIVE CREAM IF SKIN CONTACT
IS LIKELY.
Work Hygienic Practices:REMOVE & WASH CONTAM CLTHG BEFORE REUSE.
DISCARD CONTAM SHOES. DO NOT REUSE CONTAMD CLTHG. WASH HANDS BEFORE
(ING 12)
Supplemental Safety and Health
FIRE FIGHT PROC: BUILDUP & POSS AUTOIGNIT/EXPLO. EXPLO HAZ: UNRUPTURED
CNTNRS TO PVNT PRESS BUILDUP. THERM DECOMP PRODS MAY INCL HCL &
PHOSGENE . VENT: REMOVE AIRBORNE DECOMP PRODS FORMED DURING
WELDING/FLAME CUTTING ON SURFS COATED W/PROD. ALL APPLIC AREAS
SHOULD BE VENT I/A/W OSHA REG 19CFR PART 1910.94.

HCC:T4
Boiling Pt:B.P. Text:>104F,>40C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.31
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT SOLUBLE
Appearance and Odor:PURPLE LIQUID, SWEET ODOR.
Percent Volatiles by Volume:87

Stability Indicator/Materials to Avoid:YES
PRIMARY AMINES, ACIDS, WATER, HYDROXYL CONTAINING AND OTHER ACTIVE
HYDROGEN COMPOUNDS.
Stability Condition to Avoid:HIGH TEMPERATURES, MOISTURE, ALUMINUM OR
ZINC PARTS IN PRESSURIZABLE EQUIPMENT.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
OXIDES OF NITROGEN, CL*2, HC*1 AND PHOSGENE. HCL .

Waste Disposal Methods:DISPOSAL SHOULD BE DONE I/A/W FED (40CFR PART
261), ST & LOC ENVIRON CONTROL REGS. BEFORE ATTEMPTING CLEAN-UP,
REFER TO HAZ CAUTION INFO IN OTHER SECTIONS OF MSDS FORM. IF WASTE
IS DETERM TO BE HAZ, U SE LICENSED HAZ WASTE TRANSPORTER & DISP
FACILITY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.